Normally when driven piles are used as deep foundation elements, there is a large amount of pile waste when the portion of the piles left sticking up out of the ground are cut off to the desired elevation. UK piling contractor, Balfour Beatty and Finnish company Junttan have created a system that attaches to piling rigs and cuts off precast concrete piles as low as about 4 inches from the ground surface. The cut pieces are then used as starter pieces for the next pile. Balfour Beatty calculates that each precast concrete pile delivered to the site represents approximately 90 to 130 pounds of CO2 released into the atmosphere. They estimate that implementing this system on two piling rigs to date will translate into 2,000 metric tons of reduced CO2 emissions per year. [Source: Construction Enquirer via ASCE SmartBrief. Image: Construction Enquirer]
Related Articles
DFI Presents Ben C. Gerwick Award for Innovative Marine Foundations
Hawthorne, NJ (December 27, 2012): Patrick Bermingham, CEO of Bermingham Foundation Solutions, Hamilton, Ontario, Canada, was awarded the Ben C. Gerwick Award for Innovation in Design and Construction of Marine Foundations at a dinner in early December at the DFI Marine Foundation Seminar in Norfolk, Va. The annual award recognizes innovative excellence in the design and construction of marine foundations, and honors Ben C. Gerwick for his achievements during his 62-year career in the field of marine foundations. The award is sponsored by the Deep Foundation Institute Educational Trust, University of California Department of Civil and Environmental Engineering, and the Ben C. Gerwick Company.
[Editor] Click through for the rest of the press release from DFI. [/Editor]
The Use of the Pile Driving Analyzer for Installing Pile Foundations
[Editor] The pile driving analyzer or PDA is used to measure the response of piles during driving. It was originally developed to analyze pile drivability, but is sometimes used as a substitute for pile static load tests to determine . Mr. Scott A. Barnhill, P.E., Executive Vice President of consulting firm GeoEnvironmental Resources, Inc. located in Virginia Beach, Virginia has seen PDA being used and misused over his 33-year career. In this article, Mr. Barnhill describes pitfalls in relying solely on the PDA for pile capacities, and also describes what PDA is good at and how it can be used successfully. [/Editor]